Page 4 - Tech-Manual-2014

Common Parts Common Replacement Parts

This section focuses on the parts that will commonly fail in oil and gas Brand Names Include:
fired heaters. There are many parts that you can put into a heater. Desa
Hopefully, this portion of the tech book will give you a better Master
understanding of what common parts you will need to stock in your Reddy
repair shop for expedient repair service.
Remington
Knipco
Sears

One of the most common things to replace in an oil fired heater is the Filter Kit. This replacementREPLACEMENT PARTS INDEX
should be done AT LEAST once per season, or on an as needed basis. Dirty filters will cause poor
performance in your heater.

Pre-Packaged Parts

These pre-packaged parts are for the following brands: Master, Dayton, Desa, Knipco, Remington, Reddy

Below are the part numbers for the individual blister packs, the part it contains, and where used.

Helpful Hint: It is usually less expensive to order HA part kits, than ordering all of the individual parts
inside each kit.

New Old Description Compatibility
Part# Part#
PP203 HA3003 M50671-03 Safety control Non HSI models
PP204 HA3004
PP205 HA3005 M22456-1 Rotor (1/2"), (4) M8643 Blades, M22009 Various
PP206 HA3006
PP207 HA3007 M22456-2 Rotor (5/8"),(4) M8643-2 Blades, M22009 Insert Various
PP208 HA3008
PP209 HA3009 079744-01 Nozzle 35,000 BTU
PP210 HA3011
PP211 HA3012 M50597 Nozzle 50,000 BTU
PP212 HA3013
PP213 HA3014 M50880-01 Nozzle, M8882 Seal 70,000 BTU
PP214 HA3017
M51120-01 Nozzle, M8882 Seal 100-110,000 BTU
PP215 HA3018
PP216 HA3019 M18022 Nozzle, M8882 Seal 150,000 BTU before 1992
PP217 HA3020
PP218 HA3021 M10962-2 Spark plug 70, 100, 150 - non HSI
PP219 HA3024
PP220 HA3026 M29835 Spark plug 35, 50 - non HSI
PP221 HA3027
PP222 HA3028 M29632 Filter, M29633 Filter, M29612-01 Filter 35, 50, 70
PP223 HA3029
HA1170 M12179 Filter, M12244-1 Filter 100,000 BTU
PP232 HA1202
PP234 M11637 Filter, M51150-01 Fuel Filter after 1992 150,000 BTU
PP200 HA1000
PP201 HA1100 M12179 Filter, M12244-1 Filter, M11637 Filter, M19630 Fuel Filter 150,000 BTU before 1992
PP228
PP236 M16656-4 Photo Cell Various

M8940 Ball, M10993-1 Spring, M27694 Adj. Screw, M22997 Plug All models

100070-01 Nozzle Kit 55,000 BTU

Nozzle 60,000 BTU

Nozzle 70,000 BTU

Nozzle 110-115,000 BTU

Nozzle 150-155,000 BTU

Nozzle 165,000 BTU

(Safety Control / Photo Cell) Tester All Models

Heavy Duty Wheel Kit 35, 50, 70

Thermostat with numbers on dial All models w/o thermostat

Ignitor (L-shaped block type) Most HSI models

Ignitor (cigarette type) Few HSI models

Pilot ODS LP

Photocell M16656-24

—4—